Product ID:CASTROL SUPER CLEAN
MSDS Date:03/14/1995
FSC:NIIN:Submitter:D RV
Status Code:A
MSDS Number: CLNFR

CASTROL INC

1500 VALLEY ROAD
WAYNE, NJ 07474
US

Emergency Phone: 201-633-2200

Info Phone: 201-633-2200

Cage: 0B2U4

CASTROL INC

WAYNE, NJ 07474 US

Telephone: 201-633-2200

Cage: 0B2U4

ALCOHOLS ETHOXYLATED

CAS: 68439-46-3

Fraction By Weight: 1-5%

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Fraction By Weight: 60-100%

2-BUTOXYETHANOL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 5-10%

OSHA PEL 240 MG/M3;50 PPM

ACGIH TLV: 121 MG/M3;25 PPM

SODIUM GLUCONATE

CAS: 527-07-1

RTECS: LZ5235000

Fraction By Weight: 1-5%

SODIUM METASILICATE PENTAHYDRATE

CAS: 6834-92-0

RTECS: VV9275000

Fraction By Weight: 1-5%

ISONONANOIC ACID

CAS: 3302-10-1

Fraction By Weight: 1-5%

OTHER ADDITIVES

Fraction By Weight: 1-5%

DYE AND FRAGRANCE

Fraction By Weight: 0.1-1%

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: WARNING! CAUSE EYE AND SKIN
IRRITATION. EYES: CAUSES SEVERE EYE IRRITATION. AVOID CONTACT.
SKIN: CAUSES MODERATE SKIN IRRITATION. AVOID CONTACT. RESPIRATORY
SYSTEM: CAN CAUSE IRRITATION FOLLOWI NG INHALTION OF MISTS,
MAINTAIN ADEQUATE VENTILATION. INGESTION: CAN CAUSE SEVERE
IRRITATION TO DIGESTIVE TRACT. DO NOT SWALLOW. CRHONIC- NO CHRONIC
EFFECTS KNOWN.
Effects of Overexposure:EYES: SEVERE IRRITATION, REDNESS, TEARING,
PAIN; CONJUNCTIVAL SWELLING. SKIN: IRRTATION, REDNESS, EXTREME
DRYING AND PEELING, SCARRING. RESPIRATORY SYSTEM: NASAL AND
REPIRATORY IRRITATION, PNEUMONITIS , TISSUE DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.

First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF CLEAN WATER FOR AT
LEAST 15 MINUTES. CONSULT A PHYSICIAN IMMEDIATELY IF IRRITATION
PERSISTS. SKIN: REMOVE CLOTHING. IMMEDIATELY FLUSH SKIN WITH PLENTY
OF CLEAN WA TER FOR 15 MINUTES. CALL A PHYSCIAN IF IRRITATION
PERSISTS. INHALATION: REMOVE FROM AREA OF EXPOSURE. IF BREATHING IS
DIFFICULT OR IRRITATION PERSISTS, CALL A PHYSICIAN. INGESTION: DO
NOT INDUCE VOMIT ING. GIVE PLENTY OF WATER OR MILK AND CALL A
PHYSICIAN IMMEDIATELY. DO NOT GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS OR CONVULSING PERSON.

Flash Point Method:COC
Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:USE MEDIA APPROPRIATE FOR ANY SURROUNDING
COMBUSTIBLE SUBSTANCES (WATER, FOG, CO2, DRY CHEMICAL, FOAM).
Fire Fighting Procedures:COOL FIRE EXPOSED CONTAINER WITH WATER. DO NOT
ENTER CONFINED AREAS WITHOUT FULL PROTECITVE EQUIPMENT, INCLUDING A
POSITIVE PRESSURE NIOSH APPROVED SELF-CONTAININED BREATHING
APPARATUS.

Spill Release Procedures:LARGE: WEAR RESPIRATOR AND APPROPRIATE
PROTECTIVE CLOTHING. STOP SOURCE OF LEAK IF POSSIBLE. DIKE, CONTAIN
SPILL AND RECOVER FREE LIQUID. PREVENT ENTRY INTO WATERWAYS.
NEUTRALIZE AND/OR SOAK UP RESIDU E WITH AN INERT ABSORBENT SUCH AS
CLAY, SAND OR OTHER SUITABLE MATERIALS. STORE AND DISPOSE OF
PROPERLY. FLUSH AREA WITH WATER. SEE OTHER INFORMATION.

Handling and Storage Precautions:MAINTAIN AMBIENT TEMPRATURES. AVOID
PROLONGED BREATHING OF MISTS. USE WITH ADEQUATE VENTILATION. EYE
AND SKIN IRRITANT. SEVERE INTERNAL IRRITATION AND DAMAGE CAN RESULT
WHEN INGESTED. AVOID CONTACT WI TH EYES, SKIN OR CLOTHING. DO NOT
SWALLOW. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:RESPIRATORS SHOULD BE USED WHEN ENGINEERING OR
OTHER CONTROLS ARE NOT TECHNICALLY FEASIBLE. WHEN REQUIRED USE ONLY
A MSHA/NIOSH APPROVED AIR SUPPLIED RESPIRATOR OR AN AIR-PURIFYING
RESPIRATOR.
Ventilation:GENERAL VENTALATION AND LOCAL EXHAUST RECOMMENDED. BUILD UP
OF MISTS/VAPORS IN THE WORKING ATMOSPHERE MUST BE PREVENTED.
Protective Gloves:IMPERVOUS: RUBBER, NEOPRENE, NITRILE OR POLYETHYLENE.
Eye Protection:SAFETY GOGGLES OR FACE SHIELD.
Other Protective Equipment:EYE WASH AND SAFETY SHOWER RECOMMENDED IN
INDUSTRIAL SETTINGS. PROTECTIVE CLOTHING SUCH AS A COVERALL OR
APRON MAY BE USED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:AVOID SKIN AND EYE CONTACT. DO NOT WEAR
CONTAMINATED CLOTHING; LAUNDER BEFORE RE-USE OR DISCARD. WASH
THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

HCC:T6
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=-2.2C, 28.F
Vapor Pres:ND
Vapor Density:ND
Spec Gravity:1.04
pH:13.0; 2%-11.4
Viscosity:ND
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, PURPLE LIQUID; STRONG ODOR.
Percent Volatiles by Volume:80-90%

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS AND AVOID CONTACT WITH GLASS.
Stability Condition to Avoid:AVOID CONTACT WITH GLASS.
Hazardous Decomposition Products:SMOKE, FUMES, OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:IF DISCARDED AS SUPPLIED MATERIAL MEETS RCRA
CHARACTERISTIC DEFINITION OF CORROSIVITY, D002. THE TOXICITY
CHARATERISTIC HAS NOT BE EVALUATED. UNDER RCRA, THE APPLICABLE
HAZARDOUS WASTE CLASSIFICATION MUST BE EVALUATED PRIOR TO DISPOSAL
OF THE MATERIAL. SEE OTHER INFORMATION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:NOT REGULATED BY DOT

SARA Title III Information:SECTION 302/304 EXTREMELY HAZARDOUS
SUBSTANCE: N/A. CERCLA SECTION 102(A) HAZARDOUS SUBSTANCE: N/A.
SECTION 311 HAZARD CATEGORY: ACUTE (IMMEDIATE).
Federal Regulatory Information:SECTION 313 TOXIC RELEASE INVENTORY
CHEMICAL/CATEGORY: GLYCOL ETHER, 6.0 % (WT). PROP 65, THIS PRODUCT
CONTAINS ONE OR MORE CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER OR REPRODUCTIVE H ARM.
State Regulatory Information:PROP 65, THIS PRODUCT CONTAINS ONE OR MORE
CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER OR
REPRODUCTIVE HARM./P